Re: Too Much Voltage
[Date Prev][Date Next][Thread Prev][Thread Next][Date Index][Thread Index]

Re: Too Much Voltage



What does the regular meter say now (not the timing light). Unless I've missed something using the meter on the light seems to be the only thing consistent with the high reading. 

Bill Parker

On Apr 25, 2015, at 8:53 AM, carverex@xxxxxxx wrote:

Yes, it's me again. I posted earlier about concerns over discovering 15.8 V at the battery while using my new multi function timing light. After a lot of changes, I'm back where I started! I'll recap what I've done:
1) Installed Power Master 90 Amp Retro # # 17509 Alternator
2) Replaced charge wire with 8 AWG wire and routed it to the battery stud of the starter relay as suggested in many Mopar sites to bypass the ammeter.
3) Checked voltage at Idle and got 14.5 V across the battery terminals.

This all happened last fall and all was good!

This winter I added a lot of "Bling" under the hood to keep the Alternator company. Such as Edelbrock Aluminum Performer Intake, Edelbrock AVS Thunder 650 CFM carb etc..Plus a Wizard Cooling Custom Aluminum radiator (which didn't fit) :-(.
All these changes required a new Bouchillon Performance throttle bracket and kickdown cable.


So this spring I'm getting all this dialed in and I plug in my timing light and discover 15.8 V while setting timing etc.
1) I'm concerned so I verify correct reading by checking with a multimeter...I get 15.8V
2) I replace the Voltage Regulator with a new solid state unit..... No change!
3) I call Powermaster and they suggest adding an additional ground from the extra field terminal to the block..done! No change!
4) I call Powermaster, they say return the Alternator, so I take it off and ship it back.
5) I scrounge around and find the old alternator and put it back on.... NO Change! 15.8V
6) I've load tested the battery and it checks OK but I'm probably going to replace it today anyway.

Any other suggestions from the group??

I'll post a link to some visuals next.

Thanks in advance for any suggestions!

Lyle
 

--
--
--
Please address private email -- email of interest to only one person -- directly to that person. That is, email your parts/car transactions and negotiations, as well as other personal messages, only to the intended recipient. Do not just press "reply" and send your email to everyone using the general '62-'65 Clubhouse public email address. This practice will protect your privacy, reduce the total volume of mail and fine-tune the content signal to Mopar topic. Thanks!
 
1962 to 1965 Mopar Clubhouse Discussion Guidelines:
http://www.1962to1965mopar.ornocar.org/mletiq.html and http://www.1962to1965mopar.ornocar.com/general_disclaimer.html.
--
You received this message because you are subscribed to the Google Groups "The 1962 to 1965 Mopar Mail List Clubhouse" group.
http://groups.google.com/group/1962to1965mopars?hl=en.

---
You received this message because you are subscribed to the Google Groups "The 1962 to 1965 Mopar Mail List Clubhouse" group.
To unsubscribe from this group and stop receiving emails from it, send an email to 1962to1965mopars+unsubscribe@xxxxxxxxxxxxxxxx.
For more options, visit https://groups.google.com/d/optout.

--
--
--
Please address private email -- email of interest to only one person -- directly to that person. That is, email your parts/car transactions and negotiations, as well as other personal messages, only to the intended recipient. Do not just press "reply" and send your email to everyone using the general '62-'65 Clubhouse public email address. This practice will protect your privacy, reduce the total volume of mail and fine-tune the content signal to Mopar topic. Thanks!
 
1962 to 1965 Mopar Clubhouse Discussion Guidelines:
http://www.1962to1965mopar.ornocar.org/mletiq.html and http://www.1962to1965mopar.ornocar.com/general_disclaimer.html.
--
You received this message because you are subscribed to the Google Groups "The 1962 to 1965 Mopar Mail List Clubhouse" group.
http://groups.google.com/group/1962to1965mopars?hl=en.

---
You received this message because you are subscribed to the Google Groups "The 1962 to 1965 Mopar Mail List Clubhouse" group.
To unsubscribe from this group and stop receiving emails from it, send an email to 1962to1965mopars+unsubscribe@xxxxxxxxxxxxxxxx.
For more options, visit https://groups.google.com/d/optout.


Home Back to the Home of the Forward Look Network